Forums
New posts
Search forums
Image search
Shop
Amazon Store
T-Shirts
Stickers
Members
Current visitors
Supporting Member Upgrade
Sponsors
About
Log in
Register
Search
Search titles only
By:
Search titles only
By:
New posts
Search forums
Image search
Search
Search titles only
By:
Search titles only
By:
Menu
Install the app
Install
JavaScript is disabled. For a better experience, please enable JavaScript in your browser before proceeding.
You are using an out of date browser. It may not display this or other websites correctly.
You should upgrade or use an
alternative browser
.
Jeep Wrangler JK
JK General Discussion
Gas tank skid plate replacement
Reply to thread
Message
<blockquote data-quote="BigAL07" data-source="post: 444808" data-attributes="member: 21619"><p>Did mine. Had a couple of small rust holes in it and had completely rusted the outside bracket completely into. I cleaned it up best I could with a wire brush first. Prep is everything. Then put some fiberglass patches over the holes. After that I coated that mother from front to back with a product called rust doctor. It held the fiberglass in place no problem. That stuff is amazing. It turns blue in a matter of minutes. After that it turns black and sets up so hard a cat couldn’t scratch it. Covered it up with the Rubicon Express skid plate. Only had to pull 4 bolts to install it and drll 2 holes. Had a buddy that works for beer so made it a lot easier. The new plate replaced the bracket that had rusted off. Cost me case of beer but is all good now. Take your time with it. Not bad at all. Let us know how it goes. Keep jeepin.</p></blockquote><p></p>
[QUOTE="BigAL07, post: 444808, member: 21619"] Did mine. Had a couple of small rust holes in it and had completely rusted the outside bracket completely into. I cleaned it up best I could with a wire brush first. Prep is everything. Then put some fiberglass patches over the holes. After that I coated that mother from front to back with a product called rust doctor. It held the fiberglass in place no problem. That stuff is amazing. It turns blue in a matter of minutes. After that it turns black and sets up so hard a cat couldn’t scratch it. Covered it up with the Rubicon Express skid plate. Only had to pull 4 bolts to install it and drll 2 holes. Had a buddy that works for beer so made it a lot easier. The new plate replaced the bracket that had rusted off. Cost me case of beer but is all good now. Take your time with it. Not bad at all. Let us know how it goes. Keep jeepin. [/QUOTE]
Verification
Post reply
Jeep Wrangler JK
JK General Discussion
Gas tank skid plate replacement
Top
Bottom